XU Zhi qiang,LI Yao,ZHOU Ai chao,et al.Phosphate Release and Influencing Factors Analysis during Sludge Thermal Hydrolysis[J].China Water & Wastewater,2018,34(21):24-30.
污泥熱水解過程中磷的釋放規律與影響因素
- Title:
- Phosphate Release and Influencing Factors Analysis during Sludge Thermal Hydrolysis
- 文章編號:
- 1000-4602(2018)21-0024-07
- 分類號:
- TU992
- 文獻標志碼:
- A
- 摘要:
- 剩余污泥中富含磷物質，具有較大的回收利用價值。從污泥中高效回收磷最重要的步驟是將磷盡可能地釋放到溶液中。以含固率為5%的剩余污泥（干污泥中磷占比為1.1%）為研究對象，進行了熱水解磷釋放規律研究。結果顯示：當采用低溫水解與投加酸聯合處理剩余污泥時，污泥絮體被破壞，磷的釋放量顯著增加。當溫度為75 ℃、加熱時間為1 h、pH值為3時，TP和IP的釋放量可達到最大，分別為311.9 mg/L和293.8 mg/L，是原污泥液相中TP和IP含量的7.9倍和8.4倍。將經上述條件處理的污泥混合液在35 ℃下靜置24 h，污泥液相中NH+4-N濃度由96.0 mg/L提高到318.7 mg/L，同時伴隨著SCOD濃度的明顯減小。因此，通過低溫短時熱水解聯合酸處理可顯著提高污泥中磷和氨氮的釋放量，可為后續以鳥糞石沉淀法回收磷創造有利條件。
- Abstract:
- The phosphorus (P) in excess sludge (ES) produced by the sewage treatment plant has huge recycling value. The most important step of P recovery from the ES is to release as much P as possible into the solution. In this work, the ES with a solid content of 5% was used to study P release during the thermal hydrolysis. The results showed that when the ES was treated with low?temperature and pretreated with acid, the floc of the sludge was destroyed, and the release of P increased significantly. When the temperature was 75 ℃ for 1 h, the release of the total P (TP)and dissolving inorganic P (IP) in the liquid phase of raw sludge reached the maximum level, 311.9 mg/L and 293.8 mg/L, respectively, and was increased by 7.9 times and 8.4 times compared with raw sludge. When the sludge mixture was allowed to stand for 24 h at 35 ℃, the concentration of ammonia nitrogen (NH+4-N) increased from 96.0 mg/L to 318.7 mg/L, accompanied by a significant decrease in the concentration of soluble chemical oxygen demand (SCOD).These results demonstrated that the combination of low?temperature and short?time thermal and acid pretreatment could significantly increase the P and NH+4-N release in the sludge, which created favorable conditions for P recovery by struvite precipitation.
參考文獻/References:
［1］Cordell D,Drangert J O,White S. The story of phosphorus: Global food security and food for thought［J］. Global Environmental Change,2009,19(2):292-305.
［2］Rittmann B E,Mayer B,Westerhoff P,?et al?. Capturing the lost phosphorus［J］. Chemosphere,2011,84(6):846-853.
［3］Wu L,Zhang C,Hu H,?et al?. Phosphorus and short?chain fatty acids recovery from waste activated sludge by anaerobic fermentation:Effect of acid or alkali pretreatment［J］. Bioresour Technol,2017,240:192-196.
［4］Yuan Z,Pratt S,Batstone D J. Phosphorus recovery from wastewater through microbial processes［J］. Current Opinion in Biotechnology,2012,23(6):878-883.
［5］Shu L,Schneider P,Jegatheesan V,?et al?. An economic evaluation of phosphorus recovery as struvite from digester supernatant［J］. Bioresour Technol,2006,97(17):2211-2216.
［6］Wu Q,Bishop P L. Enhancing struvite crystallization from anaerobic supernatant［J］. Journal of Environmental Engineering & Science,2015,89(3):21-29.
［7］Cloete T E,Oosthuizen D J. The role of extracellular exopolymers in the removal of phosphorus from activated sludge［J］. Water Res,2001,35(15):3595-3598.
［8］Zou J,Li Y. Anaerobic fermentation combined with low?temperature thermal pretreatment for phosphorus?accumulating granular sludge:Release of carbon source and phosphorus as well as hydrogen production potential［J］. Bioresour Technol,2016,218:18-26.
［9］Steckenmesser D,Vogel C,Adam C,?et al?. Effect of various types of thermochemical processing of sewage sludges on phosphorus speciation,solubility,and fertilization performance［J］. Waste Manage,2017,62:194-203.
［10］Val del Rio A,Morales N,Isanta E,?et al?. Thermal pre?treatment of aerobic granular sludge:impact on anaerobic biodegradability［J］. Water Res,2011,45(18):6011-6020.
［11］薛濤,黃霞,郝王娟. 剩余污泥熱處理過程中磷、氮和有機碳的釋放特性［J］. 中國給水排水,2006,22(23):22-25.? Xue Tao,Huang Xia,Hao Wangjuan. Characteristics of phosphorus,nitrogen and total organic carbon release in thermal excess sludge treatment process［J］. China Water & Wastewater,2006,22(23):22-25(in Chinese).
［12］Zhang M Y,Kuba T. Inhibitory effect of metal ions on the poly?phosphate release from sewage sludge during thermal treatment［J］. Environ Technol,2014,35(9/12):1157-1162.
［13］Xu Y,Hu H,Liu J,?et al?. pH dependent phosphorus release from waste activated sludge:contributions of phosphorus speciation［J］. Chemical Engineering Journal,2015,267:260-265.
［14］Ruban V,López?Sánchez J F,Pardo P,?et al?. Harmonized protocol and certified reference material for the determination of extractable contents of phosphorus in freshwater sediments—a synthesis of recent works［J］. Fresenius Journal of Analytical Chemistry,2001,370(2/3):224-228.
［15］程振敏,魏源送,劉俊新. 酸堿預處理對常壓微波輻射剩余活性污泥磷釋放的影響［J］. 環境科學,2009,30(4):1110-1114.? Cheng Zhenmin,Wei Yuansong,Liu Junxin. Effect of acid and alkali on phosphorus release from sewage sludge in the microwave treatment process［J］. Environmental Science,2009,30(4):1110-1114(in Chinese).
［16］Weiler R R. Rate of loss of ammonia from water to the atmosphere［J］. Journal of the Fisheries Research Board of Canada,2011,36(6):685-689.
［17］陶飛飛,田晴,李方,等. 共存雜質對磷酸銨鎂結晶法回收磷的影響研究［J］. 環境工程學報,2011,5(11):2437-2441.? Tao Feifei,Tian Qing,Li Fang,?et al?. Effects of coexisting impurities on phosphorus recovery in magnesium ammonium phosphate crystallization［J］. Chinese Journal of Environmental Engineering,2011,5(11):2437-2441(in Chinese).
［18］許德超,周禮杰,尹魁浩,等. 低溫?zé)釅A破解低有機質污泥及磷形態分析［J］. 環境工程學報,2017,11(10):5621-5629.? Xu Dechao，Zhou Lijie，Yin Kuihao,?et al?. Disintegration and phosphorus forms of alkaline pretreatment with low?temperature heating for low?organic sludge［J］. Chinese Journal of Environmental Engineering,2017,11(10):5621-5629(in Chinese).
備注/Memo
基金項目：陜西省教育廳重點項目（17JS103）作者簡介：徐志嬙（1969- ），女，重慶人，博士，教授，主要從事污水再生利用與水生態修復技術研究。
E-mail:595269472@qq.com
收稿日期：2018-06-05
來源： http://zggsps.paperonce.org/oa/DArticle.aspx?type=view&id=201821005
