-
12:49已群發
-
昨天 15:46已群發
-
星期四 00:00已群發
-
星期三 00:00已群發
-
星期二 00:00已群發
-
星期一 00:00已群發
-
02月07日已群發
SONG Xiao-ya.Review of Biennial Operation of Xiaohongmen Thermal Hydrolysis Anaerobic Digestion System[J].China Water & Wastewater,2018,34(22):116-122.
小紅門污泥熱水解厭氧消化項目運行兩周年之回顧
- Title:
- Review of Biennial Operation of Xiaohongmen Thermal Hydrolysis Anaerobic Digestion System
- 文章編號:
- 1000-4602(2018)22-0116-07
- Keywords:
- sludge treatment; thermal hydrolysis; anaerobic digestion; plate and frame filter dewatering; biogas utilization
- 分類號:
- TU992
- 文獻標志碼:
- C
- 摘要:
- 小紅門熱水解厭氧消化系統,是國內首個采用康碧熱水解+厭氧消化工藝的大型污泥升級改造工程。通過回顧兩年的實際運行情況,全面總結了熱水解、厭氧消化、板框脫水的生產和技術指標,并與主要設計值進行對比。熱水解處理后的污泥含水率穩定,鏡檢顯示活性污泥破壁效果明顯,消化產氣量、有機物分解率、板框脫水后泥餅含水率等指標均優于設計指標。沼氣品質較好,但廠內利用有限,需進一步考慮沼氣的綜合利用問題。同時,針對除渣、除砂裝置運行效率低,熱水解系統稀釋水用量較多等問題,提出優化建議。
- Abstract:
- Xiaohongmen thermal hydrolysis anaerobic digestion system was the first large-scale sludge upgrading project in China which adopted Cambi thermal hydrolysis anaerobic digestion process. By reviewing two years of operation, the operation indexes of project, such as thermal hydrolysis, anaerobic digestion, plate and frame filter, were summarized and compared with the design values. The moisture of sludge treated by thermal hydrolysis was stable and the cell-wall breaking effect was obvious under microscopy. The indexes of digestion gas yield, organic matter decomposition rate and moisture content of cake after dehydration by plate and frame filter were all better than the design indexes. The quality of biogas was good, however, the utilization of biogas plant was limited at present, so the comprehensive utilization of biogas should be further considered. At the same time, the problems in actual operation were summarized, and the optimization suggestions were put forward in view of the low operation efficiency of the slag removal, sand removal devices and the large amount of dilution water in the thermal hydrolysis system.
參考文獻/References:
[1] 陳怡. 污水處理廠污泥厭氧消化工藝選擇與設計要點[J]. 給水排水,2013,39(10):41-43. Chen Yi. Key points of the process selection and design of the sludge anaerotic digestion in wastewater treatment plant[J]. Water & Wastewater Engineering,2013,39(10):41-43(in Chinese).
[2] 杜強強,戴明華,張晏,等. 熱水解厭氧消化工藝用于污水廠泥區升級改造[J]. 中國給水排水,2016,32(22):46-48. Du Qiangqiang,Dai Minghua,Zhang Yan,et al. Anaerobic digestion process of thermal hydrolysis for upgrading and rebuilding of sewage plant mud area[J].China Water & Wastewater,2016,32(22):46-48(in Chinese).
[3] 肖本益,閻鴻,魏源送. 污泥熱處理及其強化污泥厭氧消化的研究進展[J]. 環境科學學報,2009,29(4):673-682. Xiao Benyi,Yan Hong,Wei Yuansong. State of the art of thermal sludge pretreatment and its enhancement for anaerobic sludge digestion[J]. Journal of Environmental Sciences,2009,29(4):673-682(in Chinese).
[4] 韓春榮,謝繼榮,宋曉雅,等. 污水處理廠沼氣利用的經濟和能源性分析[J]. 給水排水,2012,48(12):54-57. Han Chunrong,Xie Jirong,Song Xiaoya,et al. Economy and energy analysis of the usage of methane from the wastewater treatment plant[J]. Water & Wastewater Engineering,2012,48(12):54-57(in Chinese).
[5] 張曉紅,李冰,馬文瑾,等. 溫度及熱水解對污泥厭氧消化的影響研究[A]. 2015年中國環境科學學會學術年會論文集[C]. 北京:中國環境科學學會,2015. Zhang Xiaohong,Li Bing,Ma Wenjin,et al. Effects of temperature and hydrolysis on sludge anaerobic digestion[A].Proceedings of the Annual Meeting of the Chinese Society of Environmental Sciences[C]. Beijing:Chinese Society for Environmental Sciences,2015(in Chinese).
[6] 宋曉雅,楊向平,王東生. 大型污泥厭氧消化系統的啟動與運行調控[J]. 給水排水,2011,37(3):32-34. Song Xiaoya,Yang Xiangping,Wang Dongsheng. Start up and operation of large scale anaerobic sludge digestion system[J]. Water & Wastewater Engineering,2011,37(3):32-34(in Chinese).
[7] 王社平,趙恩澤,韓蕓,等. 西安第五污水處理廠污泥消化及沼氣利用效果分析[J]. 中國給水排水, 2018,34(9):18-19. Wang Sheping,Zhao Enze,Han Yun,et al. Analysis of sludge anaerobic digestion and biogas utilization in Xi'an No.5 WWTP[J]. China Water & Wastewater,2018,34(9):18-19(in Chinese).
[8] 陶亞強,李軍,Chang Cheinchi. Blue Plains污水處理廠提標改造——后置反硝化、污泥熱水解和深層隧道[J]. 凈水技術,2016,35(1):11-15. Tao Yaqiang,Li Jun,Chang Cheinchi. Upgrading recon-struction of Blue Plains wastewater treatment plant—post-denitrification,sludge thermal hydrolysis and deep tunnels[J]. Water Purification Technology,2016,35(1):11-15(in Chinese).
[9] Leslie C P,Daigger G T,Henry C. 廢水生物處理(第2版)[M]. 張錫輝,劉勇弟,譯.北京:化學工業出版社,2003. Leslie C P,Daigger G T,Henry C. Biological Wastewater Treatment(2nd ed)[M]. Zhang Xihui,Liu Yongdi,Translation.Beijing:Chemical Industry Press,2003(in Chinese).
[10] 王平,黃鷗. 熱水解厭氧消化在污水處理廠泥區改造中的應用探討[J]. 給水排水,2015,41(10):41-45. Wang Ping, Huang Ou. Application of thermal hydrolysis anaerotic digestion in the sludge treatment upgrading project in wastewater treatment plant[J]. Water & Wastewater Engineering,2015,41(10):41-45(in Chinese).
[11] 晏發春,汪恂,張雷. 高溫熱水解預處理厭氧消化技術實例分析[J]. 中國給水排水,2016,32(18):35-37. Yan Fachun,Wang Xun,Zhang Lei. Case analysis of anaerobic digestion technology with high temperature thermal hydrolysis[J]. China Water & Wastewater,2016,32(18):35-37(in Chinese).
相似文獻/References:
[1]仝恩從.保定市污泥處理中心項目的工藝選擇及思考[J].中國給水排水,2018,34(20):21.
TONG En cong.Process Selection and Thought of Baoding Sludge Treatment Center Project[J].China Water & Wastewater,2018,34(22):21.
[2]林明,莊毅璇,李建,等.某污水處理廠污泥處理系統技術改造[J].中國給水排水,2018,34(20):109.
LIN Ming,ZHUANG Yi xuan,LI Jian,et al.Technological Transformation of Sludge Treatment System in a WWTP[J].China Water & Wastewater,2018,34(22):109.
[3]王首都,黃申斌,魏小玲,等.立式移動地板發酵倉技術在崇明某污水廠的應用[J].中國給水排水,2020,36(14):138.
WANG Shou-du,HUANG Shen-bin,WEI Xiao-ling,et al.Application of Vertical Mobile Floor Fermentation Bin in a Sewage Treatment Plant in Chongming District[J].China Water & Wastewater,2020,36(22):138.
[4]顏瑩瑩,孟春霖,梁遠,等.連續深度脫水耦合低溫干化工藝用于鷹潭污泥處理廠[J].中國給水排水,2020,36(16):105.
YAN Ying-ying,MENG Chun-lin,LIANG Yuan,et al.Continuous Deep Dewatering Coupled with Low Temperature Drying Process in Yingtan Sludge Treatment Plant[J].China Water & Wastewater,2020,36(22):105.
[5]孫建升,葉雅麗,鄭興燦,等.昆明市污水處理廠污泥處理工藝的研究與探討[J].中國給水排水,2020,36(18):108.
SUN Jian-sheng,YE Ya-li,ZHENG Xing-can,et al.Research and Discussion on the Sludge Disposal Technology of Kunming WWTPs[J].China Water & Wastewater,2020,36(22):108.
備注/Memo
作者簡介:宋曉雅(1971- ), 女, 河北石家莊人,大學本科, 教授級高級工程師, 先后參與高碑店、小紅門、槐房、高安屯等消化系統的啟動調試, 參與高碑店、延慶康莊、小紅門再生水等污水和再生水系統的調試運行工作。 E-mail:songxy@bdc.cn
收稿日期:2018-08-16
-
12:39已群發
-
昨天 16:20已群發
-
星期四 00:00已群發
-
星期三 00:00已群發
-
星期二 00:00已群發
-
星期一 00:00已群發
-
02月07日已群發
