低溫條件下微孔曝氣氧化溝中試裝置的調試及啟動
- Title:
- Commissioning and Start-up of Pilot-scale Microporous Oxidation Ditch at Low Temperature
- Keywords:
- microporous aeration oxidation ditch; low temperature; start-up; nitrogen and phosphorus removal
摘要:- 采用微孔曝氣氧化溝中試裝置處理實際污水處理廠沉砂池出水，研究了中試裝置在低溫條件下實現啟動的可行性和可靠性。結果表明，中試裝置抗沖擊負荷能力較強，在低溫條件下（13~18 ℃），控制好氧區DO濃度為0.5~1.0 mg/L，系統運行穩定；試驗后期，中試裝置出水指標除TP外其余均滿足《城鎮污水處理廠污染物排放標準》一級A標準要求。因此，在低溫條件下中試裝置可通過降低系統曝氣量實現啟動。分析了除磷效果不佳的原因，主要與排泥不規律、接種污泥除磷能力較差、回流污泥中含有硝態氮等有關。
- Abstract:
- A pilot-scale microporous aeration oxidation ditch was applied to treat the effluent from a grit chamber of a wastewater treatment plant, and the feasibility and reliability of starting up the pilot plant at low temperature were investigated. The pilot plant had strong shock load resistance, and the system operated stably at low temperatures between 13 ℃ to 18 ℃ when maintaining dissolved oxygen concentration between 0.5 mg/L and 1.0 mg/L. Except TP, the effluent quality of the pilot plant reached the first level A criteria of Discharge Standard of Pollutants for Municipal Wastewater Treatment Plant during the late period of the test. The pilot plant could be started up by reducing the aeration rate at low temperature. The reason for poor phosphorus removal was mainly related to irregular sludge discharge，poor phosphorus removal capacity of inoculated sludge and nitrate in the reflux sludge.
相似文獻/References:
[1]韓懿,張建兵,黃巍,等.曝停比對低溫單級自養脫氮系統效能影響研究[J].中國給水排水,2018,34(21):70.
HAN Yi,ZHANG Jian bing,HUANG Wei,et al.Effect of Aeration/Idle Time Ratio on Single stage Autotrophic Nitrogen Removal System at Low Temperature[J].China Water & Wastewater,2018,34(07):70.
[2]劉強,王泰,沈浡,等.MBBR工藝用于污水廠提標改造的低溫運行效果[J].中國給水排水,2020,36(13):7.
LIU Qiang,WANG Tai,SHEN Bo,et al. Operation Effect of MBBR Applied in Upgrading and Reconstruction of a Wastewater Treatment Plant in Tianjin at Low Temperature [J].China Water & Wastewater,2020,36(07):7.
[3]郝桂珍,范宇成,徐利,等.低溫下好氧顆粒污泥強化造粒研究[J].中國給水排水,2020,36(19):32.
HAO Gui-zhen,FAN Yu-cheng,XU Li,et al.Enhanced Granulation of Aerobic Granular Sludge at Low Temperature[J].China Water & Wastewater,2020,36(07):32.
