濕法煙氣脫硫廢水處理工程實例
作者:倪亭亭1， 王云鐘1， 吳永明2， 胡玲玲3， 楊春燕2， 鄧覓2（1.青島海檢節能環保有限公司，山東 青島 266235；2.江西省科學院，江西 南昌 330096；3.江西省水文監測中心，江西 南昌 330000）
PDF下載
[1]倪亭亭,王云鐘,吳永明,等.濕法煙氣脫硫廢水處理工程實例[J].中國給水排水,2022,38(4):109-113.
NITing-ting,WANGYun-zhong,WUYong-ming,et al.Case of Wet Flue Gas Desulfurization Wastewater Treatment Project[J].China Water & Wastewater,2022,38(4):109-113.點擊復制
濕法煙氣脫硫廢水處理工程實例
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第38卷 期數: 2022年第4期 頁碼: 109-113 欄目: 出版日期: 2022-02-17
Title:Case of Wet Flue Gas Desulfurization Wastewater Treatment Project
作者:倪亭亭1， 王云鐘1， 吳永明2， 胡玲玲3， 楊春燕2， 鄧覓2（1.青島海檢節能環保有限公司，山東 青島 266235；2.江西省科學院，江西 南昌 330096；3.江西省水文監測中心，江西 南昌 330000）
Author(s):NI Ting-ting1， WANG Yun-zhong1， WU Yong-ming2， HU Ling-ling3， YANG Chun-yan2， DENG Mi2（1. Qingdao Haijian Energy Conservation and Environmental Protection Co. Ltd.， Qingdao 266235， China； 2. Jiangxi Academy of Sciences， Nanchang 330096， China； 3. Jiangxi Water Resources Monitoring Center， Nanchang 330000， China）
關鍵詞:脫硫廢水; 濕式石灰石-石膏法; 化學沉淀法; 混凝沉淀
Keywords:desulfurization wastewater; wet limestone-gypsum; chemical precipitation method; coagulation sedimentation
摘要:針對某熱電廠石灰石-石膏法煙氣脫硫工藝廢渣處理系統產生的脫硫廢水，采用化學沉淀工藝進行處理，經過一年的運行發現其技術可靠、穩定，對懸浮物、COD、氟化物、汞、硫酸鹽的去除率分別達到99.5%、98.3%、87.5%、99.8%、85.6%，對應出水濃度分別為54、20、9.6、0.04、980 mg/L，出水水質滿足并優于《火電廠石灰石-石膏濕法脫硫廢水水質控制指標》（DL/T 997—2006）的要求，且電費和藥劑費合計僅為6.65 元/m3。
Abstract:The desulfurization wastewater generated by the waste residue treatment system of the limestone-gypsum flue gas desulfurization (FGD) process in a thermal power plant is treated by chemical precipitation process. After one year of operation, the technology is found reliable and stable. The removal rates of SS, COD, fluoride, mercury and sulfate reached 99.5%, 98.3%, 87.5%, 99.8% and 85.6% respectively, and the corresponding effluent concentrations were 54 mg/L, 20 mg/L and 9.6 mg/L, 0.04 mg/L, 980 mg/L. Finally, the effluent quality of the system is no less than the requirements of Discharge Standard of Wastewater from Limestone?gypsum Flue Gas Desulfurization System in Fossil Fuel Power Plants (DL/T 997-2006). In addition, the total cost of electricity and chemical is only 6.65 yuan/m3.
相似文獻/References:
[1]周明飛,連坤宙,王璟,等.電滲析技術處理脫硫廢水的效果分析[J].中國給水排水,2020,36(21):80.
ZHOU Ming-fei,LIAN Kun-zhou,WANG Jing,et al.Efficiency Analysis of Desulfurization Wastewater Treated by Electrodialysis Technology[J].China Water & Wastewater,2020,36(4):80.
更新日期/Last Update: 2022-02-17
[1]倪亭亭,王云鐘,吳永明,等.濕法煙氣脫硫廢水處理工程實例[J].中國給水排水,2022,38(4):109-113.
NITing-ting,WANGYun-zhong,WUYong-ming,et al.Case of Wet Flue Gas Desulfurization Wastewater Treatment Project[J].China Water & Wastewater,2022,38(4):109-113.
點擊復制
NITing-ting,WANGYun-zhong,WUYong-ming,et al.Case of Wet Flue Gas Desulfurization Wastewater Treatment Project[J].China Water & Wastewater,2022,38(4):109-113.
濕法煙氣脫硫廢水處理工程實例
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第38卷 期數: 2022年第4期 頁碼: 109-113 欄目: 出版日期: 2022-02-17
- Title:
- Case of Wet Flue Gas Desulfurization Wastewater Treatment Project
- 關鍵詞:
- 脫硫廢水; 濕式石灰石-石膏法; 化學沉淀法; 混凝沉淀
- Keywords:
- desulfurization wastewater; wet limestone-gypsum; chemical precipitation method; coagulation sedimentation
- 摘要:
- 針對某熱電廠石灰石-石膏法煙氣脫硫工藝廢渣處理系統產生的脫硫廢水，采用化學沉淀工藝進行處理，經過一年的運行發現其技術可靠、穩定，對懸浮物、COD、氟化物、汞、硫酸鹽的去除率分別達到99.5%、98.3%、87.5%、99.8%、85.6%，對應出水濃度分別為54、20、9.6、0.04、980 mg/L，出水水質滿足并優于《火電廠石灰石-石膏濕法脫硫廢水水質控制指標》（DL/T 997—2006）的要求，且電費和藥劑費合計僅為6.65 元/m3。
- Abstract:
- The desulfurization wastewater generated by the waste residue treatment system of the limestone-gypsum flue gas desulfurization (FGD) process in a thermal power plant is treated by chemical precipitation process. After one year of operation, the technology is found reliable and stable. The removal rates of SS, COD, fluoride, mercury and sulfate reached 99.5%, 98.3%, 87.5%, 99.8% and 85.6% respectively, and the corresponding effluent concentrations were 54 mg/L, 20 mg/L and 9.6 mg/L, 0.04 mg/L, 980 mg/L. Finally, the effluent quality of the system is no less than the requirements of Discharge Standard of Wastewater from Limestone?gypsum Flue Gas Desulfurization System in Fossil Fuel Power Plants (DL/T 997-2006). In addition, the total cost of electricity and chemical is only 6.65 yuan/m3.
相似文獻/References:
[1]周明飛,連坤宙,王璟,等.電滲析技術處理脫硫廢水的效果分析[J].中國給水排水,2020,36(21):80.
ZHOU Ming-fei,LIAN Kun-zhou,WANG Jing,et al.Efficiency Analysis of Desulfurization Wastewater Treated by Electrodialysis Technology[J].China Water & Wastewater,2020,36(4):80.
更新日期/Last Update: 2022-02-17
